At 150K miles:
-Head was rebuilt
-All engine gaskets and seals replaced (including rear main seal).
-Timing belt, tensioner, spring, idler and water pump replaced
-New brake pads and rotors
-Replaced front wheel bearings
-Radiator and hoses
-Fuel pump and filter
-K&N air filter
-PCV valve
-Accessory belts
-O2 sensor
-Cap/rotor/plugs/wires
-Thermostat & coolant
-Shocks (tokico)
-4 Tires
-Rear diff fluid
-Trans fluid
-Rad fan clutch
-Clutch, pressure plate, throw-out & pilot bearings and resurfaced flywheel
-front and rear trans seals
At 220K miles:
-New brake pads and rotors again
-Wheel bearings re-packed
-2 lifters replaced
-Valve cover gasket
-Fuel filter
-4 Tires
-Front turn signal bulbs
At 240K miles:
-All engine gaskets replaced
-Timing belt, tensioner, spring, idler and water pump replaced
-New radiator and hoses
-Fuel filter
-PCV valve
-Accessory belts
-Cap/rotor/plugs
-Thermostat & coolant
-Coil
-Rear diff fluid
-Trans fluid
-New exhaust: magnaflow catalytic converter & muffler & custom piping
-Headlights
-O2 sensor
-Clutch Master and slave cylinders
Spare parts:
-OEM Antenna
-Heater core hoses
Issues with the truck:
-Some rust on passenger side door and rear bumper (see pics)
-Rough idle sometimes, comes and goes. Maybe due to rust in the tank?
-Dent in front bumper, rest of body is straight
-Recline lever on driver side seat broke off, I use vise-grips to move it when I have to.
-One or two lifters tick on start-up about half the time but it goes away after ~5 minutes.
-AC doesn’t work, it quit on me in ’05 and I didn’t want to pay for the conversion to R-134.
-Gas gauge only works when the level gets down to ¼ tank.
-Worn drivers seat.
I always changed the oil every 3,000 miles with Shell Rotella T Synthetic and a Pure One oil filter, last oil change was at 258K. It burns about 1 quart every 1000 miles which is typical. It never smokes on start-up like most of these trucks do. It gets 24 MPG city and 28 MPG highway going 65.
If you’re interested, please respond by e-mail to natepanek at hotmail dot com.
Pics:
https://s86.photobucket.com/albums/k98/dstar26t/1990%20Mazda%20B2200%20LE-5/Asking $1,000
Thanks,
Nate